+86 15516432285

effect of quarry dust on compressive strength concrete nigeria

effect of quarry dust on compressive strength concrete nigeria

Compressive Strength and Costs of Sandcrete Blocks and ...

2013-1-28 · Compressive Strength and Costs of Sandcrete Blocks and blocks made with quarry dust in Nigeria: A Case study of Abakaliki Quarry Ikechukwu, U. F. Department of Building, Imo State University Owerri, Imo State, Nigeria. E-mail: [email protected] ABSTRACT This work focus on the analysis of compressive strength and cost of sandcrete

(PDF) EFFECT OF SULPHURIC ACID ON THE COMPRESSIVE

This study determines the effect of Sulphuric acid on the compressive strength of concrete with Quarry Dust as partial replacement of fine aggregate at 0 %, 15 %, 25 % and 35 %.

Assessment of compressive strength, durability, and ...

2021-11-17 · The effect of quarry dust-based geopolymer cement on the compressive strength, erodibility, and durability potential of expansive soils has been studied under laboratory conditions. The particular interest was on the geopolymer cement treatment of soils subgrade under hydraulically bound environments. Lateritic soils, which form the compacted foundation of pavements, tend to swell upon

Civil Engineering - University of Nigeria, Nsukka Open ...

2018-6-7 · the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete. by nnamani obinna anthony. the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature

Stone Dust in Concrete: Effect on Compressive Strength

2017-8-24 · S Shetty, 2013). The compressive strength of concrete from stone powder showed 14.76% higher value than that of the concrete made of normal sand (Mahzuz et al., 2011). It is found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present

Effect of quarry rock dust on the flexural strength of ...

2018-6-1 · The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarry-sand concrete based on its compressive strength. 3.

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · (2003) reported significant increase in compressive strength, modulus of rupture and split tensile strength when 40 percent of sand is replaced by Quarry Rock Dust in concrete. Nagaraj (2000) studied that the consumption of cement content, workability, compressive strength and cost of concrete made with Quarry Rock Dust.

STRENGTH AND DURABILITY STUDIES ON QUARRY DUST

Abstract and Figures. The main intension of the work is to study the strength and corrosion resistive properties of concrete containing Quarry dust as fine aggregate along with organic inhibitors ...

EFFECT OF PARTIAL REPLACEMENT OF SAND WITH

2020-11-17 · of sand and quarry dust were determined in the laboratory in accordance with BS 13779 (1990). - Blocks were produced using 0, 5, 10, 15, 20, 25, 30, 35, 40, 45, and 50% partial replacement of sand with quarry dust. Compressive strength tests were carried out on the blocks after curing for 7, 14, 21 and 28 days respectively.

Compressive Strength and Costs of Sandcrete Blocks and ...

2013-1-28 · Compressive Strength and Costs of Sandcrete Blocks and blocks made with quarry dust in Nigeria: A Case study of Abakaliki Quarry Ikechukwu, U. F. Department of Building, Imo State University Owerri, Imo State, Nigeria. E-mail: [email protected] ABSTRACT This work focus on the analysis of compressive strength and cost of sandcrete

Comparing the Compressive Strengths of Concrete Made

Comparing the compressive strengths of concrete made with river sand and quarry dust as fine aggregates Chijioke Chiemela1, fgwegbe talter1, Ibearugbulem Ogedi1, Okoye meter2, Oke Mong2 1Civil Engineering Department, Federal Polytechnic Nekede, Owerri, Imo State, Nigeria 2Mechanical Engineering Department, Federal Polytechnic Nekede Owerri Imo State, Nigeria

Civil Engineering - University of Nigeria, Nsukka Open ...

2018-6-7 · the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete. by nnamani obinna anthony. the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete

Stone Dust in Concrete: Effect on Compressive Strength

2017-8-24 · S Shetty, 2013). The compressive strength of concrete from stone powder showed 14.76% higher value than that of the concrete made of normal sand (Mahzuz et al., 2011). It is found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28 · (c) The compressive strength results of quarry dust concrete (cubes) were obtained in the third series, where M20, M25, and M30 grades of concrete with 20, 25, and 30 percent replacement of quarry dust and also workability are studied by varying the water-cement ratio of 0.45 and 0.50 and the results are presented.

Strength and Durability Properties of Concrete

2020-4-8 · Also the cube with 100 % quarry dust recorded 16.83 N/mm2 at maximum load as average compressive strength, giving rise to an increment of about 18 % of the compressive strength of the control specimen. Through reaction with the concrete admixture, quarry dust, thus show improved pozzolanic reaction, micro aggregate filling and concrete durability.

Experimental Study on the Properties of Concrete with ...

2019-7-1 · concrete made with 2.5% to 20% replacement of cement by quarry dust of less than 75 micron. The tests were carried out to find the compressive strength and flexural strength on specimens on specimens. Results showed that up to 7.5% replacement of cement by quarry dust, there was no reduction in compressive strength, splitting tensile strength

EFFECT OF METAKAOLIN ON COMPRESSIVE STRENGTH

2019-4-21 · 2.4 Compressive Strength Test The compressive strength test was carried out on the hardened cured concrete samples. The samples were tested using the ELE motorized compression machine. The test was conducted in accordance with BS EN 12390, Part 4 (2000) specifications. The compressive strength of the concrete cubes was determined using equation ...

EFFECT OF PARTIAL REPLACEMENT OF SAND WITH

2020-11-17 · of sand and quarry dust were determined in the laboratory in accordance with BS 13779 (1990). - Blocks were produced using 0, 5, 10, 15, 20, 25, 30, 35, 40, 45, and 50% partial replacement of sand with quarry dust. Compressive strength tests were carried out on the blocks after curing for 7, 14, 21 and 28 days respectively.

Compressive Strength and Costs of Sandcrete Blocks and ...

2013-1-28 · Compressive Strength and Costs of Sandcrete Blocks and blocks made with quarry dust in Nigeria: A Case study of Abakaliki Quarry Ikechukwu, U. F. Department of Building, Imo State University Owerri, Imo State, Nigeria. E-mail: [email protected] ABSTRACT This work focus on the analysis of compressive strength and cost of sandcrete

Comparing the Compressive Strengths of Concrete Made

Comparing the compressive strengths of concrete made with river sand and quarry dust as fine aggregates Chijioke Chiemela1, fgwegbe talter1, Ibearugbulem Ogedi1, Okoye meter2, Oke Mong2 1Civil Engineering Department, Federal Polytechnic Nekede, Owerri, Imo State, Nigeria 2Mechanical Engineering Department, Federal Polytechnic Nekede Owerri Imo State, Nigeria

Civil Engineering - University of Nigeria, Nsukka Open ...

2018-6-7 · the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete. by nnamani obinna anthony. the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete

Tasiu Ashiru Sulaiman | Ahmadu Bello University, Zaria ...

This study determines the effect of Sulphuric acid on the compressive strength of concrete with Quarry Dust as partial replacement of fine aggregate at 0 %, 15 %, 25 % and 35 %. A total of seventy-two (72) 100 mm cubes were cast and cured in water up to 28 days.

Strength and Durability Properties of Concrete

2020-4-8 · Also the cube with 100 % quarry dust recorded 16.83 N/mm2 at maximum load as average compressive strength, giving rise to an increment of about 18 % of the compressive strength of the control specimen. Through reaction with the concrete admixture, quarry dust, thus show improved pozzolanic reaction, micro aggregate filling and concrete durability.

Experimental Study on the Properties of Concrete with ...

2019-7-1 · concrete made with 2.5% to 20% replacement of cement by quarry dust of less than 75 micron. The tests were carried out to find the compressive strength and flexural strength on specimens on specimens. Results showed that up to 7.5% replacement of cement by quarry dust, there was no reduction in compressive strength, splitting tensile strength

Disqussion | COMPARATIVE ANALYSIS OF STRENGTH OF

This project work focuses on the comparative analysis of strength of concrete using sharp sand from the bed of Unwana river in Afikpo North L.G.A and quarry dust from Amasiri Quarry site in Afikpo south L.G.A. all in Ebonyi state. The concrete mix design used was 1:2:4 and unicem cement was also used in carrying out the practical as regards to ...

Study of Concrete Involving Use of Quarry dust as Partial ...

Fine aggregates were replaced by quarry dust as 0%, 10%, 20%, 30% and 40% by weight for M-25 mix. The concrete specimens were tested for compressive strength, strength, durability (water absorption) and density at 28 days of age and the results obtained were compared with those of normal concrete.

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5 · to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.